| 487 | 3 | 52 |
| 下载次数 | 被引频次 | 阅读次数 |
高硫型贝利特硫铝酸盐水泥在海洋工程快速施工具有显著的优势，但是该水泥熟料后期强度发展不足。采用硼/磷复合掺杂的方法开展了提高后期强度的研究，并采用X射线衍射结合Rietveld全谱定量分析、扫描电镜、等温量热及热重分析等测试方法，研究了硼/磷复合掺杂对高硫型贝利特硫铝酸盐水泥熟料矿物形成、微观结构及水化等的影响。研究表明：硼、磷2种元素均能固溶到硅酸二钙的晶体结构中，形成结构缺陷，提高熟料中α-C_2S含量，同时提高c-C_4A3的含量，促进了熟料早期的水化和后期强度的发展。
Abstract：Sulfate-rich belite sulfoaluminate cement is used in rapid construction of marine engineering,but the strength of the clinker developed is not enough in the later period.The improvement of the strength in the later stage was investigated via boron/phosphorus composite doping.The effect of boron/phosphorus composite doping on the mineral formation,microstructure,and hydration of high sulfur belite aluminate clinker was analyzed by X-ray diffraction combined with Rietveld full spectrum quantitative analysis,scanning electron microscopy,isothermal calorimetry and thermogravimetric analysis.The results show that boron and phosphorus both can exist in the crystal structure of dicalcium silicate,form the crystal defects,and increase the content of α-C_2S and c-C_4A_3$,thus promoting the early hydration and later strength development of the clinker.
[1]李娟,周春英,杨亚晋.高贝利特硫铝酸盐熟料矿物组成优化[J].硅酸盐学报, 2012, 40(11):1618–1624.LI Juan, ZHOU Chunying, YANG Yajin. J Chin Ceram Soc, 2012,40(11):1618–1624.
[2]兰明章,靳耀乐,葛仲熙,等.游离石膏对高贝利特硫铝酸盐水泥熟料烧成的影响[J].硅酸盐通报, 2018, 37(10)3054–3059.LAN Mingzhang, JIN Yaole, GE Zhongxi, et al. Bull Chin Ceram Soc(in Chinese), 2018, 37(10)3054–3059.
[3]杜鹏,贾斐涵,卢晓磊,等.利用固体废弃物煅烧硫铝酸盐水泥熟料研究进展[J].硅酸盐学报, 2022, 50(2):340–353.DU Peng, JIA Feihan, LU Xiaolei, et al. J Chin Ceram Soc, 2022,50(2):340–353.
[4]沈燕.利用磷石膏制备高硫型贝利特硫铝酸盐水泥的研究[D].重庆:重庆大学.SHEN Yan. Study on preparation of high sulfur belite sulphoaluminate cement from phosphogypsum(in Chinese, dissertation). Chongqing:Chongqing University.
[5]耿永娟.石油焦脱硫灰渣制备硫铝酸盐水泥的反应动力学、水化动力学及性能研究[D].青岛:青岛理工大学.GENG Yongjuan. Study on reaction kinetics, hydration kinetics and properties of sulphoaluminate cement prepared from petroleum coke desulfurization slag(in Chinese, dissertation). Qingdao:Qingdao Tehcnology University.
[6]郭伟,李东旭,陈建华,等.机械活化煅烧煤矸石水泥的早期水化过程[J].硅酸盐学报, 2008, 36(1):94–98.GUO Wei, LI Dongxu, CHEN Jianhua, et al. J Chin Ceram Soc, 2008,36(1):94–98.
[7]黎奉武,黄少文,贾江涛.利用钙铝渣和低品位铝矾土制备贝利特硫铝酸盐水泥的研究[J].水泥, 2012(6):10–12.LI Fengwu, HUANG Shaowen, JIA Jiangtao. Cement(in Chinese),2012(6):10–12.
[8] QUILLIN K. Performance of belite–sulfoaluminate cements[J]. Cem Concr Res, 2001, 31(9):1341–1349.
[9] HARGIS C W, KIRCHHEIM A P, MONTEIRO P J M, et al. Early age hydration of calcium sulfoaluminate(synthetic ye'elimite,)in the presence of gypsum and varying amounts of calcium hydroxide[J].Cem Concr Res, 2013, 48:105–115.
[10] MORSLI K, DE LA TORREáG, ZAHIR M, et al. Mineralogical phase analysis of alkali and sulfate bearing belite rich laboratory clinkers[J]. Cem Concr Res, 2007, 37(5):639–646.
[11] LI J, ZHOU Chun Ying, YANG ya jin. Effects of foreign ions on minerals of high belite-calcium sulfoaluminate cement[J]. Mater Sci Forum, 2013, 743–744:239–244.
[12] CUESTA A, LOSILLA E R, ARANDA M A G, et al. Reactive belite stabilization mechanisms by boron-bearing dopants[J]. Cem Concr Res,2012, 42(4):598–606.
[13] BENARCHID M Y, DIOURI A, BOUKHARI A, et al. Hydration of iron–phosphorus doped dicalcium silicate phase[J]. Mater Chem Phys,2005, 94(2/3):190–194.
[14] KOUMPOURI D, ANGELOPOULOS G N. Effect of boron waste and boric acid addition on the production of low energy belite cement[J].Cem Concr Compos, 2016, 68:1–8.
[15] BENARCHID M Y, ROGEZ J. The effect of Cr2O3 and P2O5 additions on the phase transformations during the formation of calcium sulfoaluminate C4A3S–[J]. Cem Concr Res, 2005, 35(11):2074–2080.
[16] ZEA-GARCIA J D, SANFELIX S G, VALLCORBA O, et al.Hydration activation of alite-belite-ye’elimite cements by doping with boron[J]. ACS Sustain Chem Eng, 2020, 8(9):3583–3590.
[17] CUBEROS A J M, DE LA TORREáG,áLVAREZ-PINAZO G, et al.Active iron-rich belite sulfoaluminate cements:clinkering and hydration[J]. Environ Sci Technol, 2010, 44(17):6855–6862.
[18] SHEN Y, YANG D Y, ZHANG M, et al. Active sulfate-rich belite sulfoaluminate cement[J]. Adv Cem Res, 2017, 29(4):166–173.
[19] HUANG Y B, QIAN J S, KANG X J, et al. Belite-calcium sulfoaluminate cement prepared with phosphogypsum:influence of P2O5 and F on the clinker formation and cement performances[J].Constr Build Mater, 2019, 203:432–442.
[20] LI J, MA B, ZHOU C Y, et al. Study on mechanism of chemical activation for minerals of high belite-calcium sulfoaluminate clinker[J].J Sustain Cem Based Mater, 2014, 3:13–23.
[21] HUANG Y B, QIAN J S, LIU C Z, et al. Influence of phosphorus impurities on the performances of calcium sulfoaluminate cement[J].Constr Build Mater, 2017, 149:37–44.
[22] BEN HAHA M, WINNEFELD F, PISCH A. Advances in understanding ye'elimite-rich cements[J]. Cem Concr Res, 2019, 123:105778.
[23] LAI G C, NOJIRI T, NAKANO K I. Studies of the stability of β-Ca2Si O4doped by minor ions[J]. Cem Concr Res, 1992, 22(5):743–754.
[24]王燕谋,苏慕珍,张量.硫铝酸盐水泥[M].北京:北京工业大学出版社, 1999:180–202.
[25] PéREZ-BRAVO R, MORALES-CANTERO A, BRUSCOLINI M, et al. Effect of boron and water-to-cement ratio on the performances of laboratory prepared belite-ye’elimite-ferrite(BYF)cements[J].Materials, 2021, 14(17):4862.
[26] H?KFORS B, BOSTR?M D, VIGGH E, et al. On the phase chemistry of Portland cement clinker[J]. Adv Cem Res, 2015, 27:50–60.
[27] KAREN S, RUBEN S, BARBARA L. A Practical Guide to Microstructural Analysis of Cementitious Materials[M].北京:科学出版社, 2021:160–175.
基本信息:
DOI：10.14062/j.issn.0454-5648.20230300
中图分类号:TQ172.11
引用信息:
[1]张文生,安楠,张洪滔,等.硼/磷复合掺杂对高硫型贝利特硫铝酸盐熟料形成与性能的影响[J].硅酸盐学报,2023,51(11):2741-2749.DOI:10.14062/j.issn.0454-5648.20230300.
基金信息:
国家自然科学基金重点项目(51832006); 中国建材集团攻关专项资助项目(2021HX0304)
2023-08-15
2023-08-15
2023-08-15